Page 2 of 2

KDX 200 no power

Posted: 01:18 pm Jul 10 2015
by jaywhy
so flywheel key replaced......
Started on 1st kick with full power!!!! Im not sure if my harbor freight compression tester is accurate or not but if anyone is interested I will post up my numbers after a few hours on the new top end.
Thanks for all the help
This will be the first forum post ive seen where the bike will still occasionally start with a broken woodruff key. Hopefully it will help someone out in the future

Re: KDX 200 no power *SOLVED*

Posted: 01:35 pm Jul 10 2015
by ohgood
Good deal man!

Re: KDX 200 no power *SOLVED*

Posted: 04:00 pm Jul 10 2015
by diymirage
I had a TSX once, when I was quite a bit younger
I decided to replace the points on it so I pulled the flywheel and serviced the ignition
when I was ready to reinstall the flywheel I realized I had misplaced the woodruff key
it was getting late already and there were several cold beers waiting for my at a local drinking hole so I decided to eyeball it and just "hold" the flywheel in the correct place while I bolted it down
closed it up and tried to start the bike up
fired up on the first kick so I figured, allright, brewskis, here I come
I put my tools away, got my jacket and my helmet and got ready to go to the bar
I shifted the bike in first, let out the clutch...and the bike jumped backwards
(apparently I got the timing off so far it ignited and kicked the engine over backwards)

the look on the guys faces as I backed into the parking lot of the bar was PRICELESS

Re: KDX 200 no power *SOLVED*

Posted: 04:21 pm Jul 10 2015
by ohgood
diymirage wrote:I had a TSX once, when I was quite a bit younger
I decided to replace the points on it so I pulled the flywheel and serviced the ignition
when I was ready to reinstall the flywheel I realized I had misplaced the woodruff key
it was getting late already and there were several cold beers waiting for my at a local drinking hole so I decided to eyeball it and just "hold" the flywheel in the correct place while I bolted it down
closed it up and tried to start the bike up
fired up on the first kick so I figured, allright, brewskis, here I come
I put my tools away, got my jacket and my helmet and got ready to go to the bar
I shifted the bike in first, let out the clutch...and the bike jumped backwards
(apparently I got the timing off so far it ignited and kicked the engine over backwards)

the look on the guys faces as I backed into the parking lot of the bar was PRICELESS
lol !



seriously though, the kdx will ruin backwards. I've found this out on the steepest hill climbs, the hard way....

kill switch kill switch killlllllll switch!